


Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
Compare Content | Grate Furnace | Pyrolysis Gasifier |
Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
-
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
Views More -
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
Views More -
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Views More -
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%Views More





Biomass Energy in Japan | BioEnergy Consult
Jun 12, 2021 · Palm Kernel Shell is generating very good traction as a renewable energy resource and biomass commodity in Japan. This is because PKS is the cheapest biomass fuel and is available in large quantities across Southeast Asia. PKS, a biomass waste generated by palm oil mills, can be found in plentiful quantities in Indonesia, Malaysia and Thailand.
RSB Japan FIT Certification for Asia Pac Biomass Trading
Aug 24, 2021 · Asia Pac Biomass Trading Ltd (AsiaPac), a trader of Palm Kernel Shell (PKS) Biomass based out of Hong Kong has achieved RSB Certification against the RSB Japan FIT standard. PKS is a palm oil residue waste product that is used to replace fossil fuels such as coal in the generation of electricity, contributing to reduced carbon emissions in the
Reference 4 Case Examples of Biomass Towns in Japan
Case Examples of Biomass Towns in Japan (Oki, Fukuoka Prefecture) (3) Biomass Utilization Goals Waste Biomass – Food waste: 100% utilization of household and industrial food waste through separated waste collection – Human waste/septic tank sludge: 100% utilization – Sawdust waste from mushroom cultivation: Present utilizing 100%.
Introduction to basic biomass town Concept JPN
leading industries of Japan. Biomass resources is affluent in Japan. Promotion of utilization of biomass will bring new opportunity to agricultural community. Revised points Promotion of utilization of unused biomass such as rice straws and forestry residues is a key for achievement. Further promotion of utilization
Equis secures $282m funding for 50 MW biomass plant in Japan
Equis Development Pte (Equis), a major renewable energy and waste infrastructure developer in Asia-Pacific, has secured $282 million (€239 million) to build a biomass plant in Japan. Equis will build the 50 MW Niigata East Port Biomass Power Plant in Niigata, a port city on Honshu, Japan’s main island.
Japanese Biomass Policy -Biomass Town-
leading industries of Japan. Biomass resources is affluent in Japan. Promotion of utilization of biomass will bring new opportunity to agricultural community. Revised points Promotion of utilization of unused biomass such as rice straws and forestry residues are key for achievement. Further promotion of utilization of domestic biofuels
Unravelling Japan's solid biomass fuel consumption
Oct 19, 2021 · The consumption of solid biomass fuel for energy purposes in Japan has been consistently increasing at a rate of 4-8 percent per annum since 2015, exceeding 25 million tonnes (absolute dry basis) for the first time in 2020. According to Renewable Energy Institute (REI), the largest growth is seen in the “thinned wood and forest residues
Biomass Power Generation from Wood Waste | July 2021
In the Okayama Prefecture city of Maniwa, wood from forest thinning and woody waste such as the branches, leaves and bark produced in the lumbering process are being used as fuel to generate biomass power, the aim being to create a sound material-cycle society and thereby revitalize the local community. A cypress forest in Maniwa City.
Awarded 50MW class Biomass-fired Power Plant Project in Japan
Sep 28, 2021 · Regarding biomass power generation, this project is the fourth project following Kanda Biomass Power Plant (75MW class) started commercial operation in June 2021 (located in Kanda, Fukuoka, Japan). TOYO and NSE will continue to contribute to creating a carbon-neutral society by expanding our approach to renewable energy projects through
Biomass Recycling | Meiwa Co., Ltd.
Function of biomass carbonization plant. Simply put, biomass carbonization plant is a waste recycling plant that can alter almost anything organic into charcoal (called biochar) through pyrolysis. Processable ingredients include sludge, human waste, chicken manure, scrap wood, agricultural residue, food waste and water hyacinth among others.
ANDRITZ’S first biomass-fired CFB boiler in Japan reaches the
Jan 03, 2022 · The ANDRITZ biomass-fired PowerFluid circulating fluidized bed boiler with flue gas cleaning system delivered to Mitsui Engineering and Shipbuilding for the biomass power plant in Ichihara, Chiba Prefecture, has been in commercial operation since December 2020 – after fulfilling all performance guarantee parameters in November 2020 as planned.
Equis secures financing for biomass power plant in Japan
Aug 27, 2021 · Equis Development Pte Ltd (Equis), an Asia-Pacific renewable energy and waste infrastructure developer, has announced it has secured US$ 282 million (JPY 31.0 billion) of non-recourse project financing for the 50 MW Niigata East Port Biomass Power Plant in Niigata, Japan. The non-recourse project financing was committed by 14 syndication banks
Ichihara Yawatafuto Biomass Power Plant, Chiba, Japan
The Ichihara Yawatafuto biomass power plant is a proposed 75MW biomass power generation facility in Japan. Image courtesy of Amaza. The Ichihara Yawatafuto biomass power plant will use palm kernel shell (PKS), wood pellets, and demolition waste as fuel to generate electricity. Image courtesy of Tetris L.
Japan’s Biomass Market Overview - JETRO
Japan has an abundance of unused timber. In the East, the supply of unused timber exceeds demand. Methane Fermentation Plants Feedstock trends are shifting from the traditional livestock excreta and sewage sludge, to a composite of sewage sludge and food waste including industrial waste and food scraps.
Statistics Explains: Solid Biomass Consumption in Japan
Oct 18, 2021 · Since 2015, the use of solid biomass fuels has been consistently increasing at a rate of 4-8% every year, exceeding 25 million tons (hereafter, on an absolute dry basis) for the first time in 2020. The largest growth is seen in "thinned wood and forest residues" which more than tripled from 2015 to 2020, reaching 3.9 million tons in 2020.
-
Rotary Automatic Slag Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Chain Grate Semi-Gasification Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
-
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
-
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
-
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%