


Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
Compare Content | Grate Furnace | Pyrolysis Gasifier |
Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
-
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
Views More -
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
Views More -
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Views More -
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%Views More





Cassava biomass electricity generation plant-Haiqi Biomass
Cassava Waste Management and Biogas Generation Potential in Sep 05, 2018 · Agricultural products such as cassava produce huge amounts of waste when processed into consumable good
BIOGAS FROM CASSAVA PEELS WASTE - Detritus Journal
The results showed that the amount of biogas generated is 2540 cm 3 /day. The stale cassava peels and cow dung slurry and the use of NH 4 Cl pretreatment chemical gave the best biogas production and methane yield of 104,961cm 3 and 62.3% respectively. The digester sludge from the anaerobic digestion of cassava peels and cow dung showed and
(PDF) THE POTENTIAL OF CASSAVA BIOMASS FOR ENERGY PRODUCTION
Of all the different feedstocks used for bioenergy production in Africa, cassava biomass potentially offers multiple benefits for producing bioenergy such as biogas. Cassava is not yet a staple
Multivariate modelling on biomass properties of cassava stems
Characterisation of cassava stems as a biomass fuel requires the measurement of the energy content and chem- ical composition of a large number of samples with large
Bioconversion of cassava stem to ethanol using Aspergillus
As the main agricultural waste product of the cassava industry, cassava stem is a good source of lignocellulosic biomass that can be converted into bioethanol (Tanaka et al. 2019). Various researchers have reported the process and conditions of bioethanol production from cassava stem.
POTENTIAL OF CASSAVA ROOT AS A RAW MATERIAL FOR BIO COMPOSITE
About 70% to 80% of cassava produced is used exclusively for making flour in Brazil. Cassava starch is used in many sectors including the food industry, pharmaceutical industry, foundry, textiles, paper and adhesives. Cassava also has three potential bio-fuels that can be generated at an industrial scale from its biomass.
Cassava (Manihot esculenta) dual use for food and bioenergy
6 | CASSAVA AS A BIOENERGY CROP Plant biomass can be used to obtain fermentable sugars that can be easily metabolized by various microorganisms to produce high energy compounds such as ethanol and butanol, which are substitutes for petroleum-based fuels (Pandey et al., 2019). Cassava biomass has been estimated
Cassava hay: A new strategic feed for ruminants
The dried cassava biomass can either be stored in a stack or made into a bale for later storage and feeding. Cassava hay can easily be prepared in a simple square-wooden-box to obtain a 15-kg bale. A finished bale is recommended to be further sun-dried to secure dry matter of at least 85-90% and to reduce hydro-cyanic acid content.
Prediction of Root Biomass in Cassava Based on Ground
Dec 03, 2021 · Cassava as a world food security crop still suffers from an inadequate means to measure early storage root bulking (ESRB), a trait that describes early maturity and a key characteristic of improved cassava varieties. The objective of this study is to evaluate the capability of ground penetrating radar (GPR) for non-destructive assessment of cassava root biomass. GPR was evaluated for this
Research Article Science, Engineering and Health Studies 2020
animal feed) were the main raw material of biomass. The rhizome of cassava was the natural binder in this study. Both biomasses were obtained on May 2019 from Cha-um district, Phetchaburi province, Thailand, and Ban-pong district, Ratchaburi province, Thailand, respectively. The raw material and binding
The potential of cassava biomass and - ScienceDirect
Nov 01, 2014 · Potential pre-treatment techniques for cassava biomass—An overview 5.1.1. Mechanical pretreatment. Mechanical pretreatment involves the physical dispersion of substrate components thereby 5.1.2. Ultrasonic pretreatment. Laboratory scale studies using ultrasonic pretreatment have shown variable ...
Short-duration cassava genotypes for crop diversification in
Background: Short-duration (6-7 months) cassava provides opportunities to smallholder farmers for effective utilisation of resources such as land, moisture and nutrients as well as diversification of enterprise and income. The variation in biomass production and partitioning, seasonal course of growth indices, yield, quality and nutrient uptake
Bio‐sorbents from cassava waste biomass and its performance
Mar 15, 2015 · Cassava xanthogenate and their derivatives, as adsorbents to remove Pb2+ from aqueous solution, are studied based upon orthogonal factorial design. The structural and thermal properties, adsorption performance as well as equilibrium‐kinetics are comprehensively investigated with multiple tools, such as Fourier transform infrared spectroscopy, thermal gravimetric analysis (TGA), and UV
Cassava stems: a new resource to increase food and fuel
Sep 09, 2013 · The biomass of cassava stem can be as much as 50% of the root mass, but the role of cassava stems in both starch and energy production has so far been overlooked. Except for ca. 10–20% that are used for propagation, cassava stems have a long history of being found mostly non-useful, even for feed, because of their particularly woody nature.
Production of Ethanol from Cassava Peelings Using a Developed
In processing cassava tuber, the biomass left behind include peelings, leaves and roots, and in most cases, the biomass waste is not used for any economical purposes. Apart from the stem that may be used for re-planting, the peelings are usually disposed of indiscriminately, thus leading to environmental pollution. In
-
Rotary Automatic Slag Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Chain Grate Semi-Gasification Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
-
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
-
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
-
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%