


Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
Compare Content | Grate Furnace | Pyrolysis Gasifier |
Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
-
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
Views More -
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
Views More -
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Views More -
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%Views More





Review of Biomass Thermal Gasification | IntechOpen
May 24, 2016 · According to Chopra and Jain , the fixed bed gasifiers can be further divided into: updraft, Imbert downdraft, throatless downdraft, cross draft, and two-stage gasifiers. The fixed-bed gasifier is suitable for producing low heating value gas for small and medium applications [13, 26]. The downdraft gasifier is distinguished by a simple design
Cross Draft Gasification - Biofuels Academy
Cross draft gasification is one of the simplest types of gasification; the reactor for this gasification is much like the updraft gasifier in that the fuel will enter from the top and the thermochemical reaction will occur progressively as this fuel descends into the reactor. The crucial difference is that the air will be entering the gasifier from the side of the reactor, rather than from the top or the bottom.
Handbook of Biomass Downdraft Gasifier Engine Systems
A gasiier converts solid fuel to gaseous fuel. A gasifier system includes the gasification reactor itself, along with the auxiliary equipment necessary to handle the solids, gases, and eluents going into or coming rom the gasifier. The figure below shows the major components of a gasifier system and the chapters in which they are discussed
Renewable energy Blog: Cross Draft Gasifier
Jan 02, 2009 · The relatively higher temperature in cross draft gasifier has an obvious effect on gas composition such as high carbon monoxide and low hydrogen and methane content when dry fuel such as charcoal is used. Cross draft gasifier operates well on dry blast and dry fuel. Posted by nanoportal at 10:43 AM. Labels: Gasification.
Draft Guidance for Industry: Hazard Analysis and Risk-Based
Applied Nutrition at the U.S. Food and Drug Administration. Underlined text in yellow highlights represents a correction from the draft Chapter 5 that we issued for public comment in August 2016.
Hazard Analysis and Risk-Based Preventive Controls for Human
Preventive Controls for Human Food: Draft Guidance for Industry1. o Food processing equipment (e.g., insanitary equipment and utensils); o Cross-contamination between raw and cooked products;
Apparatus and process for gasification of - Justia
May 05, 2015 · Thus a careful control of the gasifier draft is necessary to reduce air leakage. Gasifier draft can be controlled at a negative (sub-atmospheric) pressure in a range of 0.01 to 0.50 inch water. One way of accomplishing this is by manually setting a fan speed (to control hot syngas temperature) and adjusting solids and oxygen feed rates to
Performance analysis of downdraft gasifier for agriwaste
draft or cross flow gasifier, tar levels are higher than 0.1%. Paulo R. Wander and Carlos (2004) reported the various level of tar gasification. Avdhesh and Sharma (2009) revealed the characteristic parameters of gasifier. This gas is used for operation of, internal combustion engine. Results and discussion
Development of an Appropriate Rice-Based Biomass Gasifier as
In terms of specific draft, which is used to determine the pressure draft requirement of the blower for the gasifier, rice husk samples obtain a higher value (6.22 to 19.40 mm H 2 O per meter) than that of rice straw samples, which is 2.74 to 2.86 mm H 2 O per meter for rice straw panicles and 4.48 to 9.40 mm H 2 O per meter for rice straw
US5226927A - Wood gasifier - Google Patents
A vertical, countercurrent, updraft reactor is provided which can be advantageously used to produce synthesis gas by the partial oxidation of a solid fuel, especially a wood particle fuel.
(PDF) IRJET- BIOMASS GASIFIER: A REVIEW | IRJET Journal
These acids generally classified as upward draft, downward draft and give rise to corrosion of gasifier. In order to prevent these cross draft gasifiers, based on the direction of air/oxygen adverse effects, moisture content must be removed from the flow in the equipment.
EP2121874A1 - Drying and gasification process - Google Patents
A process for producing syngas from a carbonaceous substance and/or treating a carbonaceous substance, the process including the following steps: a) reducing the surface moisture of the carbonaceous substance; b) reducing the inherent moisture of the carbonaceous substance; and, c) gasifying the carbonaceous substance to produce syngas, wherein at step a) the carbonaceous substance is directly
Plan Review Construction Guidelines for Retail Food Facilities
Jul 09, 2013 · around and underneath equipment can be readily accomplished. If casters are less than 6 inches in height, the equipment must be readily movable by one person. 9. Scale cross-sectional details for any sneeze-guard protection used. 10. Cross-sectional details for the discharge to any indirect waste receptacles. Include the location of
Counter Current Gasifier Market Size, Share, Trends & Forecast
The gasifier is a piece of equipment that converts organic or fossil fuel derived carbonous material into carbon monoxide. It is generally classified into Downward draft, upward, and cross draft. The upward draft is also called as counter-current gasifier. A counter-current gasifier is one of the oldest and simplest types of gasifier.
Gasification - ITI Energy Limited - FreePatentsOnline.com
A downdraft-updraft gasifier (1) and method for the gasification of biomass and waste to produce combustible effluent, the gasifier comprising: a fuel valve (22) for loading solid fuel (11) into a first oxidation zone (8); a first throat (2) defining the lower edge of the first oxidation zone (8); a second throat (4) defining the lower edge of a second oxidation zone (14); a reduction zone (5
-
Rotary Automatic Slag Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Chain Grate Semi-Gasification Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
-
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
-
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
-
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%