


Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
Compare Content | Grate Furnace | Pyrolysis Gasifier |
Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
-
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
Views More -
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
Views More -
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Views More -
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%Views More





How do Horses Help the Environment? | Environment Buddy
Jul 28, 2020 · Biomass Energy. Horses are considered to be one of the biggest contributors of renewable energy. Horses can produce up to 9.1 tons of manure every year. This manure can be converted into biomass energy that can be used on farmland. Increased production of biomass energy will definitely reduce our dependency on Fossil Fuels.
Ask an Expert: Horse manure for From Trash to Gas: Biomass Energy
Apr 18, 2019 · It is common for horses to eat grass or hay, which are both considered to be types of biomass. According to “From Trash to Gas: Biomass Energy”, "The cows eat a type of biomass (grass or hay) and turn it into the biogas, methane, in their digestive tracts." Since horses and cows share a similar diet, horse manure should be a good
Horse Waste / Manure Disposal Biomass - Selected Eco Energy
Aug 31, 2017 · Mech Selected Services. Have been involved in the design, research, development and commissioning of a biomass boiler at the Kings Troop Royal Horse artillery in Greenwich. The project in London was completed in 2015 and use’s the horse manure bedding to generate heat for the site via the boiler installed. The waste is collected in bins, which then go through an automated process, including drying and shredding before it can be burnt in the boiler.
Biomass Pelleting Machine for Turning Horse Manure into Fuel
Biomass Pelleting Machine Is Suitable for Horse Manure. Actually, when burning the pellets made from horse manure or horse bedding wastes, there is no urine smell. This is because that the manure or wastes are dried before pelletizing. The smell is gone. Besides, the heat during the pelletizing process encapsulates the pellet.
Newsela | Finland proves horse manure is a viable alternative
About 70,000 tons of manure have been collected from horse stables in Finland since 2015. An average horse produces eight to 10 tons of manure per year. That can create up to 15 megawatt hours of energy, Paalanen said. Manure from only two horses is enough to heat a single-family house for one year. With about 75,000 horses in Finland, manure
Horse Manure biomass conversion-Haiqi Biomass Gasifier Factory
Biomass - Horse Manure to Generate 100% of Electricity for Oct 05, 2017 · The manure-bedding mixture that is generated will be transported to Fortum’s Järvenpää power plant where
Horse Manure - Small Giant of Bio Energy
In 2007, 486 000 tonnes of horse manure was produced, and 46 % of it stayed in the manure yard. With the bedding material, this means 497 000 cubic metres. The annual energy outcome was thus 2 700 TJ/a. It equals approximately 65 000 tonnes of fuel oil. The consumption of fossil fuels in Finland in 2007 was 16 700 000 tonnes measured in fuel oil.
Finland uses horse manure to power entire sporting event
Oct 28, 2019 · With some 75,000 horses in Finland, manure makes another renewable energy source in the Nordic country of 5.5 million. The center-left government has made tackling the effects of climate change a
Horse race run entirely on horse manure - The Horn News
Oct 28, 2019 · An average horse produces eight to ten tons of manure per year, equaling up to 15 megawatt hours of energy, Paalanen said. Manure from only two horses is enough to heat a single-family house for one year, he added. With some 75,000 horses in Finland, manure makes another renewable energy source in the Nordic country of 5.5 million.
New Furnace Uses Horse Manure for Fuel – The Horse
Nov 09, 2006 · New Furnace Uses Horse Manure for Fuel. Investors have worked to turn manure and biomass into energy, and scientists say it could make Iowa a major producer of power. The state produces enough ...
Exergetic sustainability evaluation of horse manure biomass
The horse manure biomass was pyrolyzed in a 2.45 GHz, 1 kW single-mode microwave oven. A cylindrically-shaped quartz-glass reactor having a diameter of 100 mm and a height of 250 mm was used to contain the biomass and catalyst mix.
Manure Pellet Machine Makes Good Organic - gemco-energy.com
Horse manure pellets can be made from both horse manure and waste horse bedding. As horse manure contains straw (biomass) with high energy content, the pellets made from it can be good source of fuel. You can use the horse manure pellets in heating boiler. And if you do not care about the smell, you can use horse manure pellets at home.
Helsinki horse riding event powered by horse manure
Helsinki International Horse Show in Finland powered its event entirely on horse manure. It is the fifth year in a row that all electricity used at the event, which hosted the Longines FEI World Cup Jumping qualifier, was generated from 100% horse manure. Over 150 megawatt-hours of energy was created from the 100 tonnes of manure collected from
Horsepower, literally: Finnish horse show runs on manure
Oct 28, 2019 · Over 150 megawatt hours of energy generated from 91 tonnes of manure produced by competitors. Sergio Alvarez Moya of Spain, with horse Jet Run, takes 2nd place at the Longines FEI Jumping World
Spooner farmer uses horse ‘poo-bricks’ for heat - Chickadee
Jan 27, 2020 · She learned one horse’s daily amount of manure, together with the bedding material, has 30 kWh of energy. This amount equals about three liters of fuel oil. In recent years, greater attention has been given to the use of biomass material as an alternative fuel source.
-
Rotary Automatic Slag Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Chain Grate Semi-Gasification Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
-
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
-
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
-
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%