


Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
Compare Content | Grate Furnace | Pyrolysis Gasifier |
Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
-
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
Views More -
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
Views More -
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Views More -
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%Views More





Syngas Production from Microwave Gasification of Oil Palm
some gasifying agent to produce gaseous fuel. In this study, a microwave gasification test rig is designed to produce syngas from oil palm biochars. Carbon dioxide is used as the gasifying agent. Oil palm empty fruit bunch (EFB) and oil palm shell (OPS) biochars are used as the carbonaceous materials.
Effect of coconut shell in gasication kinetics of palm kernel
and multi-feed fuel source for gasication. Moreover, it also helps oset the concerns of fuel feedstock availability due to demand, seasonal variation and transportation cost for the continuous operation of biomass gasier plants in remote areas. Keywords Thermogravimetry · Palm kernel shell · Gasication · Syngas · Coconut shell ·
BIO-SYNGAS DERIVED FROM INDONESIAN OIL PALM EMPTY FRUIT BUNCH
waste such as oil palm empty fruit bunch (EFB), palm kernel shell and mesocarp fiber at palm oil mills. The oil palm EFB is one of the high carbon content biomass, which is currently used as a combustion boiler fuel with very low efficiency. It contains cellulose, hemicellulose and lignin which have high carbon and hydrogen
Biogas from Palm Oil Mill Effluent (POME) to Syngas for
Biogas from Palm Oil Mill Effluent (POME) to Syngas for Sustainable Production of Chemicals/Fuels. Y. H. TAUFIQ YAP. 1. Laboratory for Sustainable Bioenergy and Chemicals, Catalysis Science and Technology Research Centre (PutraCAT); 2. Department of Chemistry. 2. Faculty of Science, Universiti Putra Malaysia, 43400 UPM Serdang, Selangor, Malaysia.
(PDF) Syngas production from palm kernel shell and
As shown in Fig. 4, by blending the polyethylene waste with [5] He M, Xiao B, Hu Z, Li J, Guo X, Luo S. Syngas production from catalytic palm kernel shell, the total syngas production is enriched and gasification of waste polyethylene: Influence of temperature on gas yield and achieved maximum value of 87.73 vol%.
Syngas Production from Gasification of Oil Palm Fronds with
Hydrogen rich gas from oil palm biomass as a potential source of renewable energy in Malaysia. Renewable Sustainable Energy Rev., 15: 1258-1270. CrossRef | 2: Chew, T.L. and S. Bhatia, 2008. Catalytic processes towards the production of biofuels in a palm oil and oil palm biomass-based biorefinery. Bioresour. Technol., 99: 7911-7922. CrossRef |
Frontiers | Syngas Production From Palm Kernel Shells With
Jul 28, 2020 · Palm kernel shell was dried in the oven at 80°C for 24 h prior to being placed in the gasifier with the amount of 1 kg. Air was pumped at a constant rate of 25 L/min to the gasifier to maintain biomass to air equivalent ratio of 1:0.6. The process is comprised of a downdraft gasifier, catalytic reactor, tar condenser, and tar filter.
Hydrothermal Gasification of Palm Shell Biomass for Synthesis
One of the alternative ways in producing such fuel is to utilize biomass by the hydrolysis process. In this study the effects of reaction times (10 to 70 min), reaction temperatures (180 to 260 °C ), and biomass to water mass ratio (1:1 to 1:9) were evaluated relative to the hydrolysis of palm shell particles in a low temperature (below 300
Syngas production from palm kernel shell and polyethylene
Oct 01, 2014 · Energy from renewable source is expected to complement the energy derived from fossil fuel resources. Gasification is a versatile thermochemical process for solid waste fuel conversion. In the current paper, syngas production from palm kernel shell (PKS) and polyethylene waste blend in a catalytic steam gasification process is studied.
Syngas Production from Steam Gasification of Palm Kernel
Oct 17, 2017 · The current work is based on the simulation modeling of steam gasification of palm kernel shell (PKS) with CO2 capture through sorbent (CaO) using Aspen plus. The simulation model is developed using a Gibbs free energy minimization method. The objective of this work is to investigate the effect of key parameters like temperature, steam/biomass ratio, and CaO/biomass ratio on syngas yield. The
The Effect of Pretreated Palm Kernel Shell and Mukah
Jul 21, 2020 · In this study, co-gasification of palm kernel shell (PKS) and low-rank Malaysian coal (MB) was carried out in a fixed bed reactor. For the pretreated samples, PKS was torrefied at 270°C (PKSTo) and MB was preheated at 250°C (MBPr) for 1 h, respectively, prior to co-gasification at 767°C, with a biomass blending ratio of 52% and a steam flow rate of 55 mL/min.
(PDF) Palm Kernel Shell as Potential Fuel for Syngas Production
palm kernel shell (PKS), to determine its suitability for use in syngas generation. The elemental content was studied using the X-ray fluorescence spectroscopy (XRF) analysis, and the presence of
Optimization of a Biomass Micro-Gasification Process for the
Mar 07, 2016 · Ahumada, LM, Verdeza, A, & Bula, AJ. "Optimization of a Biomass Micro-Gasification Process for the Production of Synthesis Gas From Palm Shell." Proceedings of the ASME 2015 International Mechanical Engineering Congress and Exposition. Volume 6A: Energy. Houston, Texas, USA. November 13–19, 2015. V06AT07A015. ASME.
Optimizing purity and recovery of hydrogen from syngas by
Jul 24, 2019 · Kundu, B. Sen Gupta, M.A. Hashim, and G., Redzwan, Taguchi optimization approach for production of activated carbon from phosphoric acid impregnated palm kernel shell by microwave heating, Journal of Cleaner Production, 105, (2015), 420– 427.
Palm Shell Biomass Gasifier Generator-Haiqi Biomass
Palm Shell Biomass Gasifier Generator Studies of Syngas Cleaning Technologies Suitable for Power operation of biomass gasification technologies for power generation. Catalytic cracking is selected as the hot gas cleaning technology fo
-
Rotary Automatic Slag Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Chain Grate Semi-Gasification Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
-
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
-
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
-
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%