


Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
Compare Content | Grate Furnace | Pyrolysis Gasifier |
Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
-
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
Views More -
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
Views More -
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Views More -
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%Views More





Sheep manure bio-organic fertilizer production line - Shuntec
Email:kevinchen@shuntecpress.com Wechat:xinde1937 WhatsApp:+86 189 9846 0024 Address:Yinhu Industrial Zone, Tianhe District, Guangzhou city
sheep manure – Livestock and Poultry Environmental Learning
Mar 05, 2019 · This plug-and-play digester system has the ability to operate on dairy manure, bedding material, food waste, or other organic feedstocks with a combined total solids content of 15-20%. A case study would be presented that describes the site components needed, the feedstock amount and energy production, as well as biogas end use.
Sheep Manure Nutrient Analysis - Organic and NPK fertilizer
Jan 21, 2019 · The fresh sheep manure contains 0.46% of phosphorus and 0.23% of potassium, but the nitrogen content is of 0.66%. Its phosphorus and potassium content are same with other animal manure. Organic matter content is up to about 30%, far beyond the other animal manure. Nitrogen content is more than double the content in cow dung.
What Is Manure and Why Is It Such an Environmentally Valuable
Jan 26, 2022 · Manure is an organic fertilizer made from the dung of domestic livestock including horses, cows, and poultry. It may also contain urine and bedding material like straw or sawdust. Manure is an
APPENDIX C, Biomass Feedstocks Available for BIofuel Production
Biomass Feedstocks Available for Biofuel Production . Sector Category Description Agricultural Slaughter . Packing house and butcher shop tissue and bone from cattle, poultry, sheep, swine, goats, and horses; poultry feathers; dead stock (whole animals) Manure and bedding Manure from confined animal facilities (cattle, poultry, sheep, swine,
A Review on Biomass Classification and Composition, Co-Firing
Table 1. Types of biomass feedstocks used for energy purposes Supply Sector Type Example Agricultural residues Dry lignocellulosic agricultural residues Straw (maize, cereal, rice) Sugar beet leaves Residue flows from bulb sector Livestock waste Solid manure (chicken manure) Liquid manure (cattle, pigs, sheep manure) Dedicated energy crops
Animal solid waste as a potential renewable biomass energy
Jul 10, 2021 · Poultry litter and chicken manure are found to be the best sources for both biogas and bio-oil productions followed by sheep/goat manures, while cow manure was the lowest. The estimated energetic value that can be annually produced from these wastes was found to be about 10.1 × 10 6 GJ.
A Guide to Compost Sheep Manure for Organic Fertilizer
Mar 30, 2018 · Windrow sheep manure pile on the site, and sprinkle the special organic fertilizer fermentation agents on the surface of raw materials. In general, if the water content of sheep manure is higher, people need to add moderate dry materials for mixing, so as to lower moisture. The moisture should be controlled within 60%-65% because too high (bad
ANIMAL MANURE AS RAW MATERIAL FOR VERMICOMPOSTING
Aug 08, 2012 · sheep manure contain more nitrogen and phosphorous than cattle manure. It is also known to supply more nitrogen to the plants (Balasubramanian, et al., 2009). The concentrations of total C, P and K in goat manure vermicasts are higher than those in cattle manure vermicasts. Cattle manure vermicasts had a higher N content than goat
Sheep Manure Bio-organic Fertilizer Production Line| Sheep
Sheep manure has a high content of organic fertilizer, good quality, and fineness of manure. The caloric value of sheep manure is between horse manure and cow manure, and it is a kind of warm fertilizer suitable for sand and clay mines. Raw material: Sheep is a ruminant animal, drinking less, dry fine feces, feces discharge is also less. the
Sheep Manure waste to energy machine-Haiqi Biomass
Nov 01, 2021 · Thus, potential biogas production from cattle, pig, sheep, and poultry manure waste was 5.94 × 10 10, 1.02 × 10 11, 3.60 × 10 10, and 4.96 × 10 10 m 3 in 2017, respectively. Pig manure was the largest potential single source of biogas, accounting for 41.41% of the total ( Fig. 2 ). Get Price >>
Using Sheep Manure As Fertilizer - Is Composted Sheep Manure
Jun 29, 2021 · Sheep manure can also be used as organic mulch. Because of its low odor, sheep manure can easily be used to top dress garden beds. A garden bed that has a high level of organic matter drains well and has a high number of earthworms and soil microbial activity, all good for plants. Composting Sheep Manure. Composting sheep manure is similar to
Evaluating the Potential of Domestic Animal Manure for Biogas
Nov 20, 2020 · Average temperature of digester was increased starting from the 6 th to 10 th day in cow dung and sheep manure. In this experiment, optimum time for best biogas yield was recorded. Analysis of the gas component shows the significant volume of methane component recorded in cow dung (66.9%) followed by sheep manure (62.1%).
Sheep Manure: Compost Making and Organic Fertilizer Granules
Dec 18, 2018 · Once you lose hold of sheep manure, it is loose. 2. Add 3 kg of biological complex bacteria to 1 ton of sheep manure material or 1.5 ton of fresh sheep manure. After diluting the bacteria by 1: 300 ratio, you can evenly spray into the sheep manure materials pile. Add appropriate amount of cornmeal, corn straw, dry grass, etc. 3.
Manure Management Handbook - Northeast Recycling Council
This material is based upon work supported under a grant by the Rural Utilities S ervice, United States Department of Agricultural. Any opinions, findings, and conclusions or . recommendations expressed in this material are solely the responsibility of the authors and . do not necessarily represent the official view of the Rural Utilitie s Service.
-
Rotary Automatic Slag Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Chain Grate Semi-Gasification Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
-
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
-
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
-
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%