


Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
Compare Content | Grate Furnace | Pyrolysis Gasifier |
Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
-
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
Views More -
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
Views More -
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Views More -
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%Views More





Cane Trash as Biomass Fuel | BioEnergy Consult
Feb 11, 2022 · Sugarcane trash (or cane trash) is an excellent biomass resource in sugar-producing countries worldwide. The amount of cane trash produced depends on the plant variety, age of the crop at harvest and soil and weather conditions. Typically it represents about 15% of the total above ground biomass at harvest which is equivalent to about 10-15
Sugarcane Trash as Biomass Resource - BioEnergy Consult
Feb 11, 2022 · Sugarcane trash can also converted in biomass pellets and used in dedicated biomass power stations or co-fired with coal in power plants and cement kilns. Burning of cane trash creates pollution in sugar-producing countries Currently, a significant percentage of energy used for boilers in sugarcane processing is provided by imported bunker oil.
Sugar Industry-Sustainable Source of Bio-Energy - IJERT
Jan 02, 2021 · Abstract The importance of Bio-energy/Renewable energy is now greatly acknowledged in view of growing awareness about environmental sustainability and fast depleting fossil fuels and other conventional sources of energy. Sugar factories processing sugarcane can be a potential source of bio-energy producing electricity using bagasse & cane trash, bio-ethanol through use of molasses, juice or bagasse and production of bio- gas, compressed bio-methane or bio-CNG utilizing filter cake/ press mud
Review of sugarcane trash recovery systems for energy
Apr 01, 2014 · In South Africa, the most recent value reported is 12.3% and is used in this assessment to determine the yield of trash from sugarcane stalks. The trash recovery efficiency reported in the literature range from 25% to over 80% and a value of 50% is assumed to be attainable in South Africa.
Sugar Cane Biomass - Bioenergy LAMNET
Increase energy production during crushing season with new boilers (efficiency 85-90%) and steam turbines at steam pressure higher than 28 bar New power plant, connected to sugar mill, running all year round fueled by sugar cane biomass FUEL SOURCES ENERGY 100 58 6 64 CANE SUGAR 60 27 6 33 CANE TOTAL Biomass % Trash % Bagasse % Agricultural
CANE, SUGAR AND THE ENVIRONMENT
A comparison of the energy value of the cane biomass and the energy consumed in its harvest and cultivation shows a ratio of 20:1. This makes sugar cane a biomass of enormous interest at present, as alternatives are under study to reduce the rate of gas accumulation and consequent global warming, as a result of the use of fossil fuels.
(PDF) Review of sugarcane trash recovery systems for energy
Results The average total input (EI) and output (Eo) energy for sugarcane cultivation were 146.15 + 11.16 GJ ha−1 and 961.02 ± 83.73 GJ ha−1, respectively. The energy share of sugarcane and
Sugar Cane Trash biomass conversion technologies-Haiqi
Types Of Garbage: Dispose Of Domestic Waste: It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) Area (300t/D) 40-50 Acres Higher: 30-40 Acres Lower: Operating Cost Fly Ash Emissions: Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage
BKD BIO ENERGY - Mustard/Saw Dust/Sugar Cane Briquettes - BKD
Oct 13, 2021 · BKD BIO ENERGY has established the image of a quality-conscious organization as a Supplier of Biomass Briquettes, Mustard Husk Briquettes. Open today until 17:00 Call 093168 00046 Get directions WhatsApp 093168 00046 Message 093168 00046 Contact Us Get Quote Find Table Make Appointment Place Order View Menu
Sugarcane Trash as Feedstock for Biorefineries: Agricultural
Jan 01, 2018 · Sugarcane trash is a feasible feedstock for second generation ethanol production, and according to U.S. Department of Energy (2016), about 60% of sugarcane trash in the USA is available at farm gate prices of US$40 per dry ton, and 100% at US$50 per dry ton or less. 2.2. Biomass Supply Chain.
Biomass Power Generation: Sugar Cane Bagasse and Trash
It can be 11–12 MW/1000 tcd. By integration of cane-based CHP with concentrating solar thermal (CST) – parabolic trough concentrators (PTC) systems of even size, the heat rate (power only) can
Guyana Energy Agency
1. Crop Residue - Sugar cane trash, weed, corn and crop stubble, straw, spoiled fodder, etc. Studies have shown that the content of water soluble substances such as sugars, amino acids, proteins and mineral constituents decreases with age of the plant and it is low enough to limit the rate of the digestion process.
Bio-Circular Economy: an Opportunity for Diversification for
Apr 19, 2022 · Press mud cake (PMC) is one of the world’s most abundant sugarcane-based wastes, and in an Indian context, 8–10 million tonnes per annum is produced. The current use of PMC is restricted to use as filler material in bio-composting process or directly as fertilizer to improve soil fertility without any previous recovery of value-added products. However, considering its potential, only
Greenhouse gas savings potential of sugar cane bio-energy
In fact, cane trash could prove to be an efficient energy resource due to its higher energy content than bagasse, i.e., 15.5 MJ/kg for cane trash as compared to 7.5 MJ/ kg for bagasse [13
Sugarcane Bioenergy - ScienceDirect
Jan 01, 2015 · If the energy cane is used as raw material we would have higher productivity (137 t of industrial stalks and 24 t of trash) and by using 60% of the trash, considering a TRS equal to the current cultivars, a final balance of the same 6 t sucrose, 3500 liters of ethanol and a electricity surplus coming from burning the bagasse (9.8 MWh) and trash
-
Rotary Automatic Slag Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Chain Grate Semi-Gasification Burner
Applicable raw materials: wood chips, straw briquette, bark, building templates, pellets
Diameter: <10cm Moisture content: <15% -
Waste Gasification Power Plant
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
-
Waste Gasifier
Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste and medical waste.
-
Biomass Gasification Power Plant
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
-
Biomass Gasifier
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%